Tailings dam

From Infogalactic: the planetary knowledge core
Jump to: navigation, search

A tailings dam is typically an earth-fill embankment dam used to store byproducts of mining operations after separating the valuable fraction from the uneconomic fraction of an ore. Conventional water retention dams can serve this purpose, but due to cost, a tailings dam is more viable. Tailings can be liquid, solid, or a slurry of fine particles. Solid tailings are often used as part of the structure itself.

Tailings dams rank among the largest engineered structures on earth. The Syncrude Mildred Lake Tailings Dyke in Alberta, Canada, is an embankment dam about 18 kilometres (11 mi) long and from 40 to 88 metres (131 to 289 ft) high. It is the largest dam structure on earth by volume, and as of 2001 it was believed to be the largest earth structure in the world by volume of fill.[1]

There are key differences between tailings dams and the more familiar hydro dams. Tailings dams are designed for permanent containment, meant to "remain there forever".[2] Copper, gold, uranium and other mining operations produce varied kinds of waste, much of it toxic, which pose varied challenges for long-term containment.[3]

An estimated 3,500 active tailings impoundments stand around the world, although there is no complete inventory, and the total number is disputed. As of 2000 these structures experience known "major" failures of about 2 to 5 annually, along with 35 "minor" failures.[4] Assuming the 3,500 figure is correct, this failure rate is "more than two orders of magnitude higher than the failure rate of conventional water retention dams".[5]

Structure

Unlike water retention dams, a tailings dam is raised in succession throughout the life of the particular mine. Typically, a base or starter dam is constructed, and as it fills with a mixture of tailings and water, it is raised. Material used to raise the dam can include the tailings (depending on their size) along with dirt.[6]

There are three raised tailings dam designs, the upstream, downstream and centerline, named according to the movement of the crest during raising. The specific design used is dependent upon topography, geology, climate, the type of tailings, and cost. An upstream tailings dam consists of trapezoidal embankments being constructed on top but toe to crest of another, moving the crest further upstream. This creates a relatively flat downstream side and a jagged upstream side which is supported by tailings slurry in the impoundment. The downstream design refers to the successive raising of the embankment that positions the fill and crest further downstream. A centerlined dam has sequential embankment dams constructed directly on top of another while fill is placed on the downstream side for support and slurry supports the upstream side.[7][8]

List of largest tailings dams

<templatestyles src="Module:Hatnote/styles.css"></templatestyles>

Rank Name[9] Country Year completed Structure height [m] Structure volume[10] [106 m3] Reservoir volume [109 m3] Installed capacity [MW] Type
1 Syncrude Tailings Dam Mildred MLSB[11]  Canada 1995 88 540[12]/720 0.35 NA TE
2 Syncrude Tailings Dam Mildred SWSS[13]  Canada 2010 40-50 119[12] 0.25[12] NA TE
3 ASARCO Mission Mine Tailings Dam  United States 1973 30[14] 40.1 0 [15] NA ER

Type: TE - Earth; ER - Rock-fill; PG - Concrete gravity; CFRD - Concrete face rock fill

Concerns

The standard of public reporting on tailings dam incidents is poor. A large number remain completely unreported, or lack basic facts when reported. There is no comprehensive database for historic failures. [16]

Failure rate

The lack of any comprehensive tailings dam database has prevented meaningful analysis, either gross comparisons (such as county to country comparisons, or tailings dam failures versus hydro dam failure rates) or technical failure analysis to help prevent future incidents. The records are very incomplete on crucial data elements: design height of dam, design foot print, construction type (upstream, downstream, center line), age, design life, construction status, ownership status, capacity, release volume, runout, etc.

An interdisciplinary research report from 2015 recompiled the official global record on tailings dam failures and major incidents and offered a framework for examining the severity and consequence of major incidents. That report shows a correlation between failure rates and the pace of copper ore production, and also establishes a relationship between the pursuit of lower grades of ore, which produces larger volumes of waste, and increasingly severe incidents.[17][18]

Environmental damage

The mining and processing byproducts collected in tailings dams are not part of the aerobic ecological systems, and are unstable. They may damage the environment by releasing toxic metals (arsenic and mercury among others), by acid drainage (usually by microbial action on sulfide ores), or by damaging aquatic wildlife that rely on clear water.[19]

Tailings dam failures involving significant ecological damage include:

Tailings ponds can also be a source of acid drainage, leading to the need for permanent monitoring and treatment of water passing through the tailings dam. For instance in 1994 the operators of the Olympic Dam mine, Western Mining Corporation, admitted that their uranium tailings containment had released of up to 5 million m3 of contaminated water into the subsoil. [24] The cost of mine cleanup has typically been 10 times that of mining industry estimates when acid drainage was involved.[25]

Casualties

The following table of the deadliest known tailings dam failures is not comprehensive, and the casualty figures are estimates.

Dam/incident Year Location Fatalities Details
1962 Huogudu, China tailing pond failure September 1962 Huogushan (?) or Huogudu, China 171 Few details available. A tailings pond at a tin mine operated by Yunnan Tin Group collapsed. One source reports 171 killed and another 92 injured; another has the date as September 26.[26][27]
Mina Plakalnitsa 1966-05-01 Vratsa, Bulgaria 480+ A tailings dam at Plakalnitsa copper mine near the city of Vratsa failed. A total 450,000 cu m of mud and water inundated Vratsa and the nearby village of Zgorigrad, which suffered widespread damage. The official death toll is 107, but the unofficial estimate was more than 480.[28]
Certej dam failure 1971-10-30 Certej Mine, Romania 89 A tailings dam built too tall collapsed, flooding Certeju de Sus with toxic tailings.[29]
Buffalo Creek Flood 1972-02-26 West Virginia, United States 125 Unstable loose constructed dam created by local coal mining company, collapsed in heavy rain. 1,121 injured, 507 houses destroyed, over 4,000 left homeless.
Val di Stava dam 1985-07-18 Tesero, Italy 268 Poor maintenance and low margin for error in design; outlet pipes failed, leading to pressure on dam and sudden collapse. Ten people were ultimately convicted of manslaughter and other charges.
Mufulira 1970 Zambia 89 A tailings reservoir breached and collapsed into the copper mine below it, killing 89 night-shift workers. [30]
Aberfan disaster 1966-10-21 Wales 144 The collapse and landslide of a spoil tip accumulated above the mining town on geologically unstable ground killed 28 adults and 116 children (not an engineered structure)
Hpakant jade mine disaster 2015-10-25 Myanmar 113 A slag heap reportedly used by multiple operators in this jade-mining region became unstable and flooded into nearby residences (not an engineered structure) [31]
El Cobre landslide 1965-03-28 Chile 300 Shaking from a magnitude 7.1 earthquake caused failure of two tailings dams at the El Soldado copper mine. The resulting flow destroyed the town of El Cobre.
Taoshi landslide 2008-09-08 Linfen, Shanxi Province, China 254+ Iron mine tailings, formerly administered by the state and then put into private hands, collapsed into a village at 8 a.m.[32]

See also

References

  1. Lua error in package.lua at line 80: module 'strict' not found.
  2. http://www.pbs.org/wgbh/frontline/article/tailings-dams-where-mining-waste-is-stored-forever/
  3. http://www.vancouversun.com/technology/tailings+dams+work/10102756/story.html?__lsa=60ea-4ffb
  4. http://www.infomine.com/publications/docs/Martin2000.pdf
  5. http://www.infomine.com/library/publications/docs/Azam2010.pdf
  6. Lua error in package.lua at line 80: module 'strict' not found.
  7. Lua error in package.lua at line 80: module 'strict' not found.http://mining.ubc.ca/files/2013/03/Dirk-van-Zyl.pdf
  8. Lua error in package.lua at line 80: module 'strict' not found.
  9. Talk:List of largest dams in the world#Phantom Dams
  10. Talk:List of largest dams in the world#Structure Volume
  11. D. Nicol (1994) "The Syncrude Mildred Lake Tailings Dyke Redesign", 18th Int. Congr. Large Dams.
  12. 12.0 12.1 12.2 Estimate based on height, dimensions from Google Earth and, where available, cross section. Accuracy ±15%
  13. Lua error in package.lua at line 80: module 'strict' not found.
  14. Estimate based on structure volume and dimensions from Google Earth
  15. Zero reservoir size because full of tailings
  16. http://www.infomine.com/library/publications/docs/Azam2010.pdf
  17. http://csp2.org/files/reports/Bowker%20%26%20Chambers%20-%20Risk-Public%20Liability-Economics%20of%20Tailings%20Storage%20Facility%20Failures%20%E2%80%93%2023Jul15.pdf
  18. http://www.csp2.org/tailings-dam-failures-1915-2014
  19. Franks, DM, Boger, DV, Côte, CM, Mulligan, DR. 2011. Sustainable Development Principles for the Disposal of Mining and Mineral Processing Wastes. Resources Policy. Vol. 36. No. 2. pp 114-122
  20. http://tvuol.uol.com.br/video/boechat-mariana-e-a-maior-tragedia-ambiental-do-brasil-04024C9B3162DCB15326
  21. http://www.ihu.unisinos.br/noticias/549187-e-a-maior-tragedia-ambiental-do-brasil-mas-tem-solucao
  22. "Death of a river", BBC, February 15, 2000
  23. http://www.eenews.net/stories/1059957572
  24. http://www.world-nuclear.org/info/nuclear-fuel-cycle/mining-of-uranium/environmental-aspects-of-uranium-mining/
  25. Lua error in package.lua at line 80: module 'strict' not found., page 452-458
  26. The present situation and prospects for safety online-monitoring system of tailings pond (sic), by ZHOU Hanmin, YUAN Ziqing, SU Jun, YANG Xiaocong and ZHANG Da1, paper presented for the 3rd International Conference on Mechatronics, Robotics and Automation (ICMRA 2015)
  27. http://resources.alibaba.com/topic/800030605/Introduction_tailings_dam.htm
  28. http://zgorigrad.com/tragediata
  29. Lua error in package.lua at line 80: module 'strict' not found.
  30. http://www.tailings.info/casestudies/mufulira.htm
  31. http://www.aljazeera.com/news/2015/11/deaths-reported-myanmar-jade-collapse-151122032719542.html
  32. http://www.asianews.it/news-en/Taoshi-landslide:-hundreds-dead,-mine-owner-and-government-accused-13188.html

Further reading