Spin (aerodynamics)

From Infogalactic: the planetary knowledge core
(Redirected from Spin (flight))
Jump to: navigation, search

<templatestyles src="Module:Hatnote/styles.css"></templatestyles>


An aircraft in a descending spin.

A spin is a special category of stall resulting in autorotation about the vertical axis and a shallow, rotating, downward path. Spins can be entered intentionally or unintentionally, from any flight attitude if the aircraft has sufficient yaw while at the stall point. [1] In a normal spin, the wing on the inside of the turn is stalled while the outside wing remains flying; it is possible for both wings to be stalled but the angle of attack of each wing, and consequently its lift and drag, will be different.[2] Either situation causes the aircraft to autorotate (yaw) toward the stalled wing due to its higher drag and loss of lift. Spins are characterized by high angle of attack, an airspeed below the stall on at least one wing and a shallow descent. Recovery may require a specific and counterintuitive set of actions in order to avoid a crash.

A spin differs from a spiral dive in which neither wing is stalled and which is characterized by a low angle of attack and high airspeed. A spiral dive is not a type of spin because neither wing is stalled. In a spiral dive, the aircraft will respond conventionally to the pilot's inputs to the flight controls and recovery from a spiral dive requires a different set of actions from those required to recover from a spin.[3]

In the early years of flight, a spin was frequently referred to as a "tailspin".[4] A method used to control a spin before it fully develops is a maneuver called the falling leaf.

How a spin occurs

Aerodynamic spin diagram: lift and drag coefficients vs. angle of attack

Many types of airplane will only spin if the pilot simultaneously yaws and stalls the airplane (intentionally or unintentionally). Under these circumstances, one wing will stall, or stall more deeply than the other. The wing that stalls first will drop, increasing its angle of attack and deepening the stall. At least one wing must be stalled for a spin to occur. The other wing will rise, decreasing its angle of attack, and the aircraft will yaw towards the more deeply stalled wing. The difference in lift between the two wings causes the aircraft to roll, and the difference in drag causes the aircraft to yaw.

One common scenario that can lead to an unintentional spin is an uncoordinated turn toward the runway during the landing sequence. A pilot who is overshooting the turn to final approach may be tempted to apply rudder to increase the rate of turn. The result is twofold: the nose of the airplane drops below the horizon and the bank angle increases. Reacting to these unintended changes, the pilot may then begin to pull the elevator control aft (thus increasing the angle of attack) while applying opposite aileron to decrease bank angle. Taken to its extreme, this can result in an uncoordinated turn with sufficient angle of attack to cause the aircraft to stall. This is called a cross-control stall, and is very dangerous if it happens at low altitude where the pilot has little time to recover. In order to avoid this scenario, pilots are taught the importance of always making coordinated turns. Certificated, light, single-engine airplanes must meet specific criteria regarding stall and spin behaviour. Spins can also be entered intentionally for training, flight testing, or aerobatics.

Phases

A climbing spin, requiring good thrust-to-weight ratio.

In aircraft that are capable of recovering from a spin, the spin has four phases.[5] For all or some types of spin, some airplanes are not recoverable. At low height, recovery may also be impossible. In both cases, only the first three phases occur.

  • Entry – The pilot stalls the plane while in uncoordinated[6] flight.
  • Incipient – With one wing more stalled than the other, the rotation starts.
  • Developed – The aircraft's rotation rate, airspeed, and vertical speed are stabilized. At least one wing of the aircraft is stalled.[7]
  • Recovery – After appropriate control inputs, the angle of attack of both wings decreases below the critical angle of attack, rotation slows. The nose attitude of the aircraft steepens, airspeed increases, autorotation stops, the aircraft is no longer stalled. The controls respond conventionally and the airplane can be returned to normal flight.

Modes

The U.S. National Aeronautics and Space Administration (NASA) has defined four different modes of spinning. These four modes are defined by the angle of attack of the airflow on the wing.[8]

NASA Spin Mode Classification
Spin mode Angle-of-attack range, degrees
Flat 65 to 90
Moderately flat 45 to 65
Moderately steep 30 to 45
Steep 20 to 30

During the 1970s NASA used its spin tunnel at the Langley Research Center to investigate the spinning characteristics of single-engine general aviation airplane designs. A 1/11-scale model was used with nine different tail designs.[9]

Some tail designs that caused inappropriate spin characteristics had two stable spin modes — one steep or moderately steep; and another that was either moderately flat or flat. Recovery from the flatter of the two modes was usually less reliable or impossible. The further aft that the center of gravity was located the flatter the spin and the less reliable the recovery.[10] For all tests, the center of gravity of the model was at either 14.5% of Mean Aerodynamic Chord (MAC) or 25.5% of MAC.[11]

Single-engine airplane types certified in the normal category must be demonstrated to recover from a spin of at least one turn, while single-engine aircraft certified in the utility category must demonstrate a six turn spin that cannot be unrecoverable at any time during the spin due to pilot action or aerodynamic characteristic.[12] NASA recommends various tail configurations and other strategies to eliminate the flatter of the two spin modes and make recovery from the steeper mode more reliable.[13]

History

In aviation's early days, spins were poorly understood and often fatal. Proper recovery procedures were unknown, and a pilot's instinct to pull back on the stick served only to make a spin worse. Because of this, the spin earned a reputation as an unpredictable danger that might snatch an aviator's life at any time, and against which there was no defense.

The spin was initially explored by individual pilots performing ad-hoc experiments (often accidentally) and by aerodynamicists. Lincoln Beachey was able to exit spins at will according to Harry Bruno in Wings over America (1944). In August 1912, Lieutenant Wilfred Parke RN became the first aviator to recover from an accidental spin when his Avro Type G biplane entered a spin at 700 feet AGL in the traffic pattern at Larkhill. Parke attempted to recover from the spin by increasing engine speed, pulling back on the stick, and turning into the spin, with no effect. The aircraft descended 450 feet, and horrified observers braced themselves for a fatal crash.

Parke was disabled by centrifugal forces but was still considering a means of escape. In an effort to neutralize the forces pinning him against the right side of the cockpit, he applied full right rudder, and the aircraft leveled out fifty feet[14] above the ground. With the aircraft now under control, Parke climbed, made another approach, and landed safely.

In spite of the discovery of "Parke's technique", spin-recovery procedures were not a routine part of pilot training until well into World War I.

The first documented case of an intentional spin and recovery is that of Harry Hawker.[15] In the summer of 1914, Hawker recovered from an intentional spin over Brooklands, England, by centralizing the controls.

In 1917, the English physicist Frederick Lindemann conducted a series of experiments that led to the first understanding of the aerodynamics of the spin.

During the 1920s and 1930s, before night-flying instruments were commonly available on small aircraft, pilots were often instructed to enter a spin deliberately in order to avoid the much more dangerous graveyard spiral when they suddenly found themselves enveloped in clouds, hence losing visual reference to the ground. In almost every circumstance, the cloud deck ends above ground level, giving the pilot a reasonable chance to recover from the spin before impacting the surface.

Today, spin training is not required for private pilot certification; added to this, most training type aircraft are placarded "intentional spins prohibited". Some model Cessna 172's are certified for spinning, although they can be difficult to actually get into a spin. Generally, though, spin training is undertaken in an "Unusual attitude recovery course" or as a part of an aerobatics endorsement (though not all countries actually require training for aerobatics). However, understanding and being able to recover from spins is certainly a skill that a fixed-wing pilot could learn for safety. It is routinely given as part of the training in sailplanes, since gliders often operate slowly enough to be in turning, near-stall conditions. Because of this, in the U.S. demonstration of spin entry and recovery is still required for glider instructor certification. In Canada, spins are a mandatory exercise to get the commercial license, and are demonstrated for the private license.[16][17]

Entry and recovery

Some aircraft cannot be recovered from a spin using only their own flight control surfaces and must not be allowed to enter a spin under any circumstances. If an aircraft has not been certified for spin recovery, it should be assumed that spins are not recoverable and are unsafe in that aircraft. Important safety equipment, such as stall/spin recovery parachutes, which generally are not installed on production aircraft, are used during testing and certification of aircraft for spins and spin recovery.

Spin-entry procedures vary with the type and model of aircraft being flown but there are general procedures applicable to most aircraft. These include reducing power to idle and simultaneously raising the nose in order to induce an upright stall. Then, as the aircraft approaches stall, apply full rudder in the desired spin direction while holding full back-elevator pressure for an upright spin. Sometimes a roll input is applied in the direction opposite of the rudder (i.e., a cross-control).

If the aircraft manufacturer provides a specific procedure for spin recovery, that procedure must be used. Otherwise, to recover from an upright spin, the following generic procedure may be used: Power is first reduced to idle and the ailerons are neutralized. Then, full opposite rudder (that is, against the yaw) is added and held to counteract the spin rotation, and the elevator control is moved briskly forward to reduce the angle of attack below the critical angle. Depending on the airplane and the type of spin, the elevator action could be a minimal input before rotation ceases, or in other cases the elevator control may have to be moved to its full forward position to effect recovery from the upright spin. Once the rotation has stopped, the rudder must be neutralized and the airplane returned to level flight. This procedure is sometimes called PARE, for Power idle, Ailerons neutral, Rudder opposite the spin and held, and Elevator through neutral. The mnemonic "PARE" simply reinforces the tried-and-true NASA standard spin recovery actions—the very same actions first prescribed by NACA in 1936, verified by NASA during an intensive, decade-long spin test program overlapping the 1970s and '80s, and repeatedly recommended by the FAA and implemented by the majority of test pilots during certification spin-testing of light airplanes.

Inverted spinning and erect or upright spinning are dynamically very similar and require essentially the same recovery process but use opposite elevator control. In an upright spin, both roll and yaw are in the same direction but that an inverted spin is composed of opposing roll and yaw. It is crucial that the yaw be countered to effect recovery. The visual field in a typical spin (as opposed to a flat spin) is heavily dominated by the perception of roll over yaw, which can lead to an incorrect and dangerous conclusion that a given inverted spin is actually an erect spin in the reverse yaw direction (leading to a recovery attempt in which pro-spin rudder is mistakenly applied and then further exacerbated by holding the incorrect elevator input).

In some aircraft that spin readily upright and inverted, such as Pitts- and Christen Eagle-type high-performance aerobatic aircraft, an alternative spin-recovery technique may effect recovery as well, namely: Power off, Hands off the stick/yoke, Rudder full opposite to the spin (or more simply "push the rudder pedal that is hardest to push") and held (aka the Mueller/Beggs technique). An advantage of the Mueller/Beggs technique is that no knowledge of whether the spin is erect or inverted is required during what can be a very stressful and disorienting time. Even though this method does work in a specific subset of spin-approved airplanes, the NASA Standard/PARE procedure can also be effective provided that care must be taken to ensure the spin does not simply cross from positive to negative (or vice versa) and that a too-rapid application of elevator control is avoided as it may cause aerodynamic blanketing of the rudder rendering the control ineffective and simply accelerate the spin. The converse, however, may not be true at all—many cases exist where Beggs/Mueller fails to recover the airplane from the spin, but NASA Standard/PARE will terminate the spin. Before spinning any aircraft the flight manual should be consulted to establish if the particular type has any specific spin recovery techniques that differ from standard practice.

Although entry techniques are similar, modern military fighter aircraft often tend to require yet another variation on spin recovery techniques. While power is still typically reduced to idle thrust and pitch control neutralized, opposite rudder is almost never used. Adverse yaw created by the rolling surfaces (ailerons, differential horizontal tails, etc.) of such aircraft is often more effective in arresting the spin rotation than the rudder(s), which usually become blanked by the wing and fuselage due to the geometric arrangement of fighters. Hence, the preferred recover technique has a pilot applying full roll control in the direction of the rotation (i.e., a right-hand spin requires a right stick input), generally remembered as "stick into the spin". Likewise, this control application is reversed for inverted spins.

Center of gravity

The characteristics of an airplane with respect to spinning are significantly influenced by the position of the center of gravity. In general terms, the further forward the center of gravity the less readily the airplane will spin, and the more readily it will recover from a spin. Conversely, the further aft the center of gravity the more readily the airplane will spin, and the less readily it will recover from a spin. In any airplane, the forward and aft limits on center of gravity are carefully defined. In some airplanes that are approved for intentional spinning, the aft limit at which spins may be attempted is not as far aft as the aft limit for general flying. Intentional spinning should not be attempted casually, and the most important pre-flight precaution is to determine that the airplane's center of gravity will be within the range approved for intentional spinning.

Unrecoverable spins

The DH 108—the missile-shaped objects on the wing tips are containers for anti-spin parachutes.

If the center of gravity of the airplane is behind the aft limit approved for spinning, any spin may prove to be unrecoverable except by using some special spin-recovery device such as a spin-recovery parachute specially installed in the tail of the airplane;[18] or by jettisoning specially installed ballast at the tail of the airplane.

Some World War II airplanes were notoriously prone to spins when loaded erroneously, such as the Bell P-39 Airacobra. The P-39 was a unique design with the engine behind the pilot's seat and a large cannon in the front. Without ammunition or a counterbalance load in the nose compartment, the P-39's center of gravity was too far aft to recover from a spin. Soviet pilots did numerous tests of the P-39 and were able to demonstrate its dangerous spinning characteristics. Bell then issued a recommendation to bail out if the airplane entered a power on left spin that developed into a flat spin.[citation needed] North American P-51 Mustangs with auxiliary fuel tanks not originally designed for the P-51 suffered from the same problem.[citation needed] Similarly, the Vought F4U Corsair was reputed to have appalling stall and spin recovery characteristics, even in the "clean" (no stores) configuration.[citation needed] The Me 210 design was fatally compromised by design faults causing both spin and hunting oscillation flight behaviours.[citation needed]

Modern fighter aircraft are not immune to the phenomenon of unrecoverable spin characteristics. Another example of a nonrecoverable spin occurred in 1963, with Chuck Yeager at the controls of the NF-104A rocket-jet hybrid: during his fourth attempt at setting an altitude record, Yeager lost control and entered a spin, then ejected and survived. On the other hand, the Cornfield Bomber was a case where the ejection of the pilot shifted the center of gravity enough to let the now-empty aircraft self-recover from a spin and land itself.

T-tail airliners, especially those like the Tupolev Tu-154 and Hawker Siddeley Trident, are also prone to the spin:[19] their centers of gravity are commonly far aft, due to heavy engines in the rear end of the fuselage and T-tail construction usually being more complex and thus heavier than the normal empennage. This is exacerbated by the tendency of a T-tail to enter deep stall as the angle of attack goes above the critical value, leading to the complete loss of authority in the tail, followed by a slow spin with the nose above the horizon. On the Tu-154 and Trident, this is considered an unrecoverable position[20] and has led to a number of high-profile crashes, such as British European Airways Flight 548[21] and Aeroflot Flight 7425.[22]

An airplane spin tends to flatten as it progresses because then its mass is distributed furthest from its center of rotation, as rotating objects tend to rotate about their axis of maximum rotational inertia. Aircraft have their maximum rotational inertia when spinning on their normal axis, i.e. flatly.

In purpose-built aerobatic aircraft, spins may be intentionally flattened through the application of power and aileron within a normal spin. Rotation rates experienced are dramatic and can exceed 400 degrees per second in an attitude that may even have the nose above the horizon. Such maneuvers must be performed with the center of gravity in the normal range and with appropriate training, and consideration should be given to the extreme gyroscopic forces generated by the propeller and exerted on the crankshaft. The current world record for the number of consecutive spins is 81, held by Spencer Suderman in 2014 in a Pitts S2-B from 23,000ft altitude.[23]

Aircraft design

For safety, all certificated, single-engine fixed-wing aircraft, including certificated gliders, must meet specified criteria regarding stall and spin behavior. Complying designs typically have a wing with greater angle of attack at the wing root than at the wing tip, so that the wing root stalls first, reducing the severity of the wing drop at the stall and possibly also allowing the ailerons to remain somewhat effective until the stall migrates outward toward the wing tip. One method of tailoring such stall behavior is known as washout. Some designers of recreational aircraft seek to develop an aircraft that is characteristically incapable of spinning, even in an uncoordinated stall.

Some airplanes have been designed with fixed leading edge slots. Where the slots are located ahead of the ailerons, they provide strong resistance to stalling and may even leave the airplane incapable of spinning.

The flight control systems of some gliders and recreational aircraft are designed so that when the pilot moves the elevator control close to its fully aft position, as in low speed flight and flight at high angle of attack, the trailing edges of both ailerons are automatically raised slightly so that the angle of attack is reduced at the outboard regions of both wings. This necessitates an increase in angle of attack at the inboard (center) regions of the wing, and promotes stalling of the inboard regions well before the wing tips.

A US certification standard for civil airplanes up to 12,500 lb maximum takeoff weight is Part 23 of the Federal Aviation Regulations, applicable to airplanes in the normal, utility and acrobatic categories. Part 23, §23.221 requires that single-engine airplanes must demonstrate recovery from either a one-turn spin if intentional spins will be prohibited or six-turn spins if intentional spins will be approved. Even large, passenger-carrying single-engine airplanes like the Cessna Caravan must be subjected to one-turn spins by a test pilot and repeatedly demonstrated to recover within no more than one additional turn. With a small number of airplane types the FAA has made a finding of equivalent level of safety (ELOS) so that demonstration of a one-turn spin is not necessary. For example, this has been done with the Cessna Corvalis[citation needed] and the Cirrus SR20/22. Successful demonstration of the one-turn spin does not allow an airplane type to be approved for intentional spinning. If an airplane is to be approved for intentional spinning, it must be repeatedly subjected to a spin of six turns and then demonstrated to recover within one and a half additional turns. Spin testing is a potentially hazardous exercise and the test aircraft must be equipped with some spin-recovery device such as a tail parachute or jettisonable ballast, or some method of rapidly moving the center of gravity forward.

Agricultural airplanes are typically certificated in the normal category at a moderate weight. For single-engine airplanes this requires successful demonstration of the one-turn spin. However, with the agriculture hopper full these airplanes are not intended to be spun and recovery is unlikely. For this reason, at weights above the maximum for the normal category, these airplanes are not subjected to spin testing and, as a consequence, can only be type certificated in the restricted category. As an example of an agricultural airplane, see the Cessna AG series.

Spin kit

To make some sailplanes spin easily for training purposes or demonstrations, a spin kit is available from the manufacturer.

Many training aircraft may appear to be resistant to entering a spin even though some are intentionally designed and certified for spins. A well-known example of an aircraft designed to spin readily is the Piper Tomahawk, which is certified for spins, though the Piper Tomahawk's spin characteristics remain controversial.[24] Aircraft that are not certified for spins may be difficult or impossible to recover once the spin exceeds the one-turn certification standard.

Although it has been removed from most flight test syllabuses, there are some countries that still require flight training on spin recovery. In the U.S. spin training is required for civilian flight instructor candidates and military pilots.[25] A spin occurs only after a stall, so the FAA emphasizes training pilots in stall recognition, prevention, and recovery as a means to reduce accidents due to unintentional stalls and/or spins.

A spin is often intimidating to the uninitiated, however many pilots trained in spin entry and recovery find that the experience builds awareness and confidence. In a spin, the occupants of the airplane will only feel reduced gravity during the entry phase and then will experience normal gravity, except that the extreme nose-down attitude will press the occupants forward against their restraint harnesses. The rapid rotation, combined with the nose-down attitude, results in a visual effect called "ground flow", and can be disorienting.

The recovery procedure from a spin requires using rudder to stop the rotation, then elevator to reduce angle of attack to stop the stall, then pulling out of the dive without exceeding the maximum permitted airspeed (VNE) or maximum G loading. The maximum G loading for a light airplane in the normal category is usually 3.8 G. For a light airplane in the acrobatic category it is usually at least 6 G.

References

  • Airplane Flying Handbook, ch. 4: Slow Flight, Stalls, and Spins
  • NASA Technical Note TN D-6575 Summary of Spin Technology as Related to Light General-Aviation Airplanes. Retrieved 2011-06-04
  • NASA Technical Paper 1009 Spin-tunnel Investigation of the Spinning Characteristics of Typical Single-engine General Aviation Airplane Designs. Retrieved 2011-06-04
  • Stengel, R. (2004), Flight Dynamics, Princeton University Press, ISBN 0-691-11407-2
  • Lua error in package.lua at line 80: module 'strict' not found.

Notes

  1. Lua error in package.lua at line 80: module 'strict' not found.
  2. http://www.av8n.com/how/htm/spins.html
  3. Lua error in package.lua at line 80: module 'strict' not found.
  4. Lua error in package.lua at line 80: module 'strict' not found.
  5. Stinton, Darryl (1996), Flying Qualities and Flight Testing of The Aeroplane, Chapter 5 (p.503), Blackwell Science Ltd, Oxford UK. ISBN 0-632-02121-7
  6. "Uncoordinated" flight means the airplane has a non-zero Angle of sideslip.
  7. Spin modes
  8. NASA Technical Paper 1009. p.11
  9. NASA Technical Paper 1009. p.8
  10. NASA Technical Note TN D-6575. p.15
  11. NASA Technical Paper 1009. p.9
  12. United States Federal Aviation Regulations, Part 23, §23.221
  13. NASA Technical Paper 1009. p.14
  14. History of Aerobatics – Jet Fighter School 2 by Richard G. Sheffield
  15. Engine-out spin
  16. FLIGHT INSTRUCTOR Practical Test Standards for GLIDER October 2006, p. 1-50
  17. http://www.tc.gc.ca/fra/aviationcivile/publications/tp13462-ex13-2263.htm
  18. "Parachute in Tail of Plane Pulls Ship Out of a Spin" Popular Mechanics, January 1936 note—drawing of anti-spin chute in P-26 for reference only. In actuality, anti-spin chute must be located in extreme end of tail—i.e., location shown would not work in emergency
  19. Aviation Today article discussing Pulkovo Aviation Enterprise Flight 612 with comments on the aircraft design.
  20. Aviation Safety Network description of Trident entering a spin during flight testing.
  21. ASN description of Staines crash.
  22. ASN Report of Uchkuduk disaster.
  23. Lua error in package.lua at line 80: module 'strict' not found.
  24. http://www.pipertomahawk.com/stallspin.htm
  25. http://ecfr.gpoaccess.gov/cgi/t/text/text-idx?c=ecfr&sid=62510df6166eef6322c923fc4ed332a7&rgn=div5&view=text&node=14:2.0.1.1.2&idno=14#14:2.0.1.1.2.8.1.4

External links